Must watch: Toyota Celica Rally History Options

[tomazws]

http://video.google.com/videoplay?docid=-8...503751&q=celica

too bad the 6th is not in the video :\

[vincent_doggy]

http://video.google.com/videoplay?docid=-8...503751&q=celica

too bad the 6th is not in the video :\

Some History for interest reading:

Toyota was the first Japanese company that tried, and later succeeded, to beat European manufacturers in the World Rally Championship. Their Celica has gone through many mutations since it first took part in world class rallying back in 1988 in the Tour de Corse rally. As usual Japanese manufacturers come up with a new version of their cars every two years. This didn't seem to cause too many problems to Toyota Team Europe, the team that prepares the racing cars. There was always a period of adapting a new model to rally racing but this usually took less than three months.

The commercial versions of the Celica went through a number of updates starting with the original ST165 (1987-1989) going to the ST185 (the bio-design car, 1990-1992) and lastly the ST205 (1993-1999). The competition cars followed this evolution closely.

The first 4WD version (ST165) suffered mainly from heat problems not having enough air circulating in the engine compartment. This problem was partially fixed in the ST185 with the addition of an engine bonnet vent. The ST205 was the most accomplished version, aerodynamically speaking.



Group A Celica (ST-205)

The Celica has been a hard to beat contender ever since its introduction in the WRC when it raced against the Lancia Integrale in 1989-90. Toyota won 38 WRC rallies and 2 WRC Championships ('93 and '94) with it.

The Toyota team was promised to success up to the Catalunya rally in 1995 when an FIA commissioner discovered a weird device in Didier Auriol's Celica ST205.
To limit the horsepower in rally cars the FIA has regulated the use of a turbo restrictor. This is device, resembling a tube, with a regulations specified dimensions fits in the turbocharger's air intake to limit the air flow and consequently the engine's output. Toyota engineers had mounted the restrictor in a way that it would slightly move from its original position, allowing more air into the turbocharger, when the car was running. This of course was prohibited and as a consequence Toyota was excluded from the World Rally Championship. Too bad for their drivers, Juha Kankkunen, Didier Auriol and Armin Schwarz at the time, who declared they knew nothing whatsoever about the presence of such a device in their cars. No one ever found out whether the device came from Toyota Japan or from Toyota Team Europe. Either way each party must have known about its presence.

That was a really sad moment for the rally racing world. Especially so because Toyota was one of the most (if not the most) innovating teams around. They, first, introduced hydro-electronic differentials, they introduced the A.L.S. (a.k.a. bang-bang) engine management system as well as the "joystick" gear change interface (in the Corolla WRC) among many other innovations.

Anyway back to the car now, the Celica GTFour was based on the production Celica versions and looked almost exactly like one. The latest street version of the car contained some very fine engineering. The 2 liter 4 in-line engine was derived from the atmospheric (non turbocharged) version and delivered anywhere from 220 Bhp in its first versions to 242 Bhp in the latest street GTFour. Turbo lag time was kept within reason due to the use of a small, in-house, CT-20 turbocharger. Many technical innovations where present in this engine and car. You may note among others:

An electronically controlled turbocharger (Toyota Computer Controlled System) which also handled injection and ignition

Specially shaped intake and outlet tubes

A very cleverly designed two-way catalytic converter which reduced back pressure on the turbo

A water to air intercooler whose water was cooled in an extra water cooler

Increased water and oil flows compared to older versions of the engine

The Fresh Air Intake System, a device producing almost the same effects as an A.L.S. (this was unfortunately disconnected in street cars due to excessive exhaust tube stress and noise)

4 piston aluminum brake calipers in the front wheels and 315!mm vented brake discs

Many parts of the body where in aluminum including the engine bonnet, parts of the chassis, etc.

Enjoy

This post has been edited by vincent_doggy: Jun 19, 2006 - 2:09 PM

[hurley97]

i cant remember where i found this but i put it everywhere...i love it...i<3 rally!

"It's Toyota's rare and powerful all-wheel-drive turbocharged Celica designed and built for rally. But to compete in rally, Toyota had to use a production car. So they put it into production and basically they are detuned race cars driven on the street with extreme performance potential."

ive seen a wrc clip with a 6gen in it...i will find it...later

[hurley97]

ok i found it...but i cant get microsoft movie maker to let me open it to cut out the part so you dont have to sieve through the whole thing

its in the preview to the R04 2006 WRC Rally Catalunya Costa-Durada (the spanish rally...its in the middle somewhere)

if i ever get the clip i'll post it

[WH95TE]

Is Toyota still banned from wrc?

This post has been edited by WH95TE: Jun 22, 2006 - 10:53 AM

[hurley97]

Is Toyota still banned from wrc?

the banns dont last that long...like a year or two
i know they were excluded from the wrc for the following 2 years
they switched to the corolla after that

the 7th gen was not made for rally like all the previous ones and now the celica is discontinued altogether so toyota doesnt have much of anything to enter rally with anymore